ASTM D 2832 : 1992 : R2016
Current
Current
The latest, up-to-date edition.
Standard Guide for Determining Volatile and Nonvolatile Content of Paint and Related Coatings
Published date
01-04-2016
Sorry this product is not available in your region.
CONTAINED IN VOL. 06.01, 2017 Outlines the volatile and non-volatile content of paint and associated coatings.
| Committee |
D 01
|
| DocumentType |
Guide
|
| ProductNote |
Reconfirmed 2016
|
| PublisherName |
American Society for Testing and Materials
|
| Status |
Current
|
| Supersedes |
1.1This guide is intended to aid in the selection of the proper ASTM standard for determining the volatile and nonvolatile content of paint and related coatings.
Note 1:Test methods for determining the composition of the volatile fraction are not covered by this guide.
1.2The standards included are as follows:
| Type of Coating | Section | ASTM |
| Aerosol coatings | 4.1 | D3062 |
| Architectural wall coatings, interior, high | 4.3 | D1644 |
| Asphalt roof coatings | 4.4 | D2823 |
| Asphalt roof coatings, aluminum-pigmented | 4.5 | D2824 |
| Bitumens, emulsified | 4.6 | D2939 |
| Bleached lac varnish | 4.7 | D1650 |
| Coil coatings | 4.8 | D1353 |
| Electrical insulation varnishes | 4.9 | D115 |
| House paints, gloss | | D2697 |
| Industrial baking enamel | | D2697 |
| Lacquers, clear and pigmented | 4.11 | D1644 |
| Latex paint, exterior | | D2697 |
| Latex paint, interior | | D2697 |
| Magnet wire enamels | 4.12 | D3288 |
| Plastics, coatings for | 4.13 | D1644 |
| Powder coatings | 4.14 | D3451 |
| Shellac varnish, orange | 4.7 | D1650 |
| Silanes, Siloxanes and Silane-Siloxane Blends | 4.18 | D5095 |
| Solvent-reducible coatings | 4.2 | D2369 |
| Traffic paints | 4.15 | D2205 |
| Varnishes | 4.16 | D1644 |
| Wall and trim enamels, interior semigloss, solvent-based | 4.17 | D2697 |
| Wall paints, flat | 4.10 | D2697 |
| Water-reducible coatings | 4.2 | D2369 |
1.3The values stated in SI units are to be regarded as the standard. The values given in parentheses are for information only.
1.4This standard does not purport to address all of the safety concerns, if any, associated with its use. It is the responsibility of the user of this standard to establish appropriate safety and health practices and determine the applicability of regulatory limitations prior to use.
| ASTM F 940 : 1999 : R2013 | Standard Practice for Quality Control Receipt Inspection Procedures for Protective Coatings (Paint), Used in Marine Construction and Shipbuilding |
| ASTM D 3335 : 1985 : REV A : R2014 | Standard Test Method for Low Concentrations of Lead, Cadmium, and Cobalt in Paint by Atomic Absorption Spectroscopy |
| ASTM D 3718 : 1985 : REV A : R2015 | Standard Test Method for Low Concentrations of Chromium in Paint by Atomic Absorption Spectroscopy |
| ASTM D 5201 : 2005 : REV A : R2014 | Standard Practice for Calculating Formulation Physical Constants of Paints and Coatings |
| ASTM D 3618 : 2005 : R2015 | Standard Test Method for Detection of Lead in Paint and Dried Paint Films |
| ASTM E 1868 : 2010 : R2015 | Standard Test Methods for Loss-On-Drying by Thermogravimetry |
| ASTM D 3960 : 2005 : R2018 | Standard Practice for Determining Volatile Organic Compound (VOC) Content of Paints and Related Coatings |
| ASTM D 6577 : 2015 | Standard Guide for Testing Industrial Protective Coatings |
| ASTM D 5145 : 2009 : R2014 | Standard Test Methods for Nonvolatile and Pigment Content of Electrocoat Baths |
| ASTM D 4834 : 2003 : R2014 | Standard Test Method for Detection of Lead in Paint by Direct Aspiration Atomic Absorption Spectroscopy |
| ASTM D 3717 : 1985 : REV A : R2015 | Standard Test Method for Low Concentrations of Antimony in Paint by Atomic Absorption Spectroscopy |
| ASTM D 1353 : 2013 : REDLINE | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 115 : 2017 : REDLINE | Standard Test Methods for Testing Solvent Containing Varnishes Used for Electrical Insulation |
| ASTM D 1644 : 2001 | Standard Test Methods for Nonvolatile Content of Varnishes |
| ASTM D 2697 : 2003 : R2008 | Standard Test Method for Volume Nonvolatile Matter in Clear or Pigmented Coatings |
| ASTM D 2697 : 2022 | Standard Test Method for Volume Nonvolatile Matter in Clear or Pigmented Coatings |
| ASTM D 2824 : 2002 | Standard Specification for Aluminum-Pigmented Asphalt Roof Coatings, Nonfibered, Asbestos Fibered, and Fibered without Asbestos |
| ASTM D 1353 : 2009 | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 2697 : 2003 | Standard Test Method for Volume Nonvolatile Matter in Clear or Pigmented Coatings |
| ASTM D 3288 : 1997 | Standard Test Methods for Magnet-Wire Enamels |
| ASTM D 115 : 2017 : R2024 | Standard Test Methods for Testing Solvent Containing Varnishes Used for Electrical Insulation |
| ASTM D 2369 : 1998 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 333 : 2001 : R2013 | Standard Guide for Clear and Pigmented Lacquers |
| ASTM D 1644 : 2001 : R2006 | Standard Test Methods for Nonvolatile Content of Varnishes |
| ASTM D 3451 : 2006 : R2012 | Standard Guide for Testing Coating Powders and Powder Coatings |
| ASTM D 333 : 2001 : R2021 | Standard Guide for Clear and Pigmented Lacquers |
| ASTM D 333 : 2001 | Standard Guide for Clear and Pigmented Lacquers |
| ASTM D 5095 : 1991 : R1997 : EDT 1 | Standard Test Method for Determination of the Nonvolatile Content in Silanes, Siloxanes and Silane-Siloxane Blends Used in Masonry Water Repellent Treatments |
| ASTM D 5095 : 1991 : R2007 | Standard Test Method for Determination of the Nonvolatile Content in Silanes, Siloxanes and Silane-Siloxane Blends Used in Masonry Water Repellent Treatments |
| ASTM D 2369 : 1981 : EDT 1 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 3451 : 2024 | Standard Guide for Testing Coating Powders and Powder Coatings |
| ASTM D 2369 : 2001 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2205 : 1985 : R1998 | Standard Guide for Selection of Tests for Traffic Paints |
| ASTM D 2369 : 2010 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 1644 : 2001 : R2012 | Standard Test Methods for Nonvolatile Content of Varnishes |
| ASTM D 3451 : 2006 | Standard Guide for Testing Coating Powders and Powder Coatings |
| ASTM D 2697 : 2003 : R2014 | Standard Test Method for Volume Nonvolatile Matter in Clear or Pigmented Coatings |
| ASTM D 1353 : 2003 | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 2697 : 1986 : R1998 | Standard Test Method for Volume Nonvolatile Matter in Clear or Pigmented Coatings |
| ASTM D 1644 : 2001 : R2017 | Standard Test Methods for Nonvolatile Content of Varnishes |
| ASTM D 2697 : 2003 : R2021 | Standard Test Method for Volume Nonvolatile Matter in Clear or Pigmented Coatings |
| ASTM D 115 : 1998 | Standard Test Methods for Testing Solvent Containing Varnishes Used for Electrical Insulation |
| ASTM D 2823 : 1990 : R1997 : EDT 1 | Standard Specification for Asphalt Roof Coatings, Asbestos Containing |
| ASTM D 2369 : 2020 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 3451 : 2006 : R2017 | Standard Guide for Testing Coating Powders and Powder Coatings |
| ASTM D 5095 : 1991 : R2013 | Standard Test Method for Determination of the Nonvolatile Content in Silanes, Siloxanes and Silane-Siloxane Blends Used in Masonry Water Repellent Treatments |
| ASTM D 1644 : 2001 : R2023 | Standard Test Methods for Nonvolatile Content of Varnishes |
| ASTM D 5095 : 1991 : R2002 | Standard Test Method for Determination of the Nonvolatile Content in Silanes, Siloxanes and Silane-Siloxane Blends Used in Masonry Water Repellent Treatments |
| ASTM D 115 : 2017 | Standard Test Methods for Testing Solvent Containing Varnishes Used for Electrical Insulation |
| ASTM D 2205 : 2015 | Standard Guide for Selection of Tests for Traffic Paints |
| ASTM D 2369 : 2007 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 3288 : 2003 | Standard Test Methods for Magnet-Wire Enamels |
| ASTM D 2369 : 2010 : EDT 1 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2939 : 2003 | Standard Test Methods for Emulsified Bitumens Used as Protective Coatings (Withdrawn 2012) |
| ASTM D 1353 : 1983 : EDT 1 | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 2205 : 2015 : REDLINE | Standard Guide for Selection of Tests for Traffic Paints |
| ASTM D 2205 : 1985 : R2010 | Standard Guide for Selection of Tests for Traffic Paints |
| ASTM D 2369 : 1993 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2369 : 2024 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2824 : 1994 | Standard Specification for Aluminum-Pigmented Asphalt Roof Coatings, Nonfibered, Asbestos Fibered, and Fibered without Asbestos |
| ASTM D 3451 : 1992 | Standard Practices for Testing Polymeric Powders and Powder Coatings |
| ASTM D 3062 : 1979 : R1984 | Test Method for Solids Content of Aerosol Coatings (Withdrawn 1994) |
| ASTM D 5095 : 1991 : R2022 | Standard Test Method for Determination of the Nonvolatile Content in Silanes, Siloxanes and Silane-Siloxane Blends Used in Masonry Water Repellent Treatments |
| ASTM D 2823 : 2005 | Standard Specification for Asphalt Roof Coatings, Asbestos Containing |
| ASTM D 2369 : 1995 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2369 : 2004 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2824 : 2006 | Standard Specification for Aluminum-Pigmented Asphalt Roof Coatings, Nonfibered, Asbestos Fibered, and Fibered without Asbestos |
| ASTM D 2369 : 1990 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 1650 : 1991 | Test Methods of Sampling and Testing Shellac Varnish (Withdrawn 1997) |
| ASTM D 1353 : 2013 : R2021 | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 2369 : 2003 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2939 : 1998 | Standard Test Methods for Emulsified Bitumens Used as Protective Coatings |
| ASTM D 1353 : 1996 | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 2369 : 2010 : R2015 : EDT 1 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2369 : 1987 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 3451 : 2001 | Standard Guide for Testing Coating Powders and Powder Coatings |
| ASTM D 2205 : 1985 : R2004 | Standard Guide for Selection of Tests for Traffic Paints |
| ASTM D 2369 : 2001 : EDT 1 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 1353 : 2013 | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 1353 : 2002 | Standard Test Method for Nonvolatile Matter in Volatile Solvents for Use in Paint, Varnish, Lacquer, and Related Products |
| ASTM D 2369 : 1992 | Standard Test Method for Volatile Content of Coatings |
| ASTM D 2824 : 2004 | Standard Specification for Aluminum-Pigmented Asphalt Roof Coatings, Nonfibered, Asbestos Fibered, and Fibered without Asbestos |
Access your standards online with a subscription
Features
-
Simple online access to standards, technical information and regulations.
-
Critical updates of standards and customisable alerts and notifications.
-
Multi-user online standards collection: secure, flexible and cost effective.