• VDI 2102 Blatt 2:2013-04

    Current The latest, up-to-date edition.

    Emission control - Copper and copper alloy melting plants

    Available format(s):  Hardcopy, PDF

    Language(s):  German - English

    Published date:  01-04-2013

    Publisher:  Verlag des Vereins Deutscher Ingenieure

    Add To Cart

    Table of Contents - (Show below) - (Hide below)

    Preliminary Note
    Introduction
    1. Scope
    2. Terms and definitions
    3. Technology
    4. Emission control measures
    5. Emissions values
    6. Instructions for emission measurements
    7. Waste
    8. Cooling water and waste water
    9. Energy efficiency, heat recovery
    Annex - Block diagrams of example melting plants
    Bibliography
    Term index English - German

    Abstract - (Show below) - (Hide below)

    The guideline describes the current state of the art of copper and copper alloy melting plants as well as the suitable emission reduction measures.

    General Product Information - (Show below) - (Hide below)

    Document Type Standard
    Publisher Verlag des Vereins Deutscher Ingenieure
    Status Current
    Supersedes

    Standards Referencing This Book - (Show below) - (Hide below)

    VDI 3883 Blatt 1:2015-09 Effects and assessment of odours - Assessment of odour annoyance - Questionnaires
    TRGS 557 : 2008
    VDI 2102 Blatt 1:2007-04 (Draft) Emission control - Secondary copper smelting and refining plants
    ISO/IEC 17025:2005 General requirements for the competence of testing and calibration laboratories
    DIN 1701:1980-05 REFINED NICKEL
    ISO 23210:2009 Stationary source emissions Determination of PM10/PM2,5 mass concentration in flue gas Measurement at low concentrations by use of impactors
    VDI 3677 Blatt 3:2012-11 Filtering-separators - High-temperature gas filtration
    EN 1948-2:2006 Stationary source emissions - Determination of the mass concentration of PCDDs/PCDFs and dioxin-like PCBs - Part 2: Extraction and clean-up of PCDDs/PCDFs
    VDI 3481 Blatt 1:1975-08 Gaseous emission measurement; determination of hydrocarbon concentration; flame-ionization-detector (FID)
    DIN EN 573-3:2013-12 ALUMINIUM AND ALUMINIUM ALLOYS - CHEMICAL COMPOSITION AND FORM OF WROUGHT PRODUCTS - PART 3: CHEMICAL COMPOSITION AND FORM OF PRODUCTS
    DIN EN 14791:2006-04 STATIONARY SOURCE EMISSIONS - DETERMINATION OF MASS CONCENTRATION OF SULPHUR OXIDES - STANDARD REFERENCE METHOD
    CEN/TS 14793:2005 Stationary source emission - Intralaboratory validation procedure for an alternative method compared to a reference method
    VDI 4085:2017-04 Planning, construction and managing of scrapyards - Facilities and equipment for the handling, storage and treatment of scraps and other materials
    DIN EN 1948-4:2014-03 STATIONARY SOURCE EMISSIONS - DETERMINATION OF THE MASS CONCENTRATION OF PCDDS/PCDFS AND DIOXIN-LIKE PCBS - PART 4: SAMPLING AND ANALYSIS OF DIOXIN-LIKE PCBS
    DIN EN 14790:2006-04 STATIONARY SOURCE EMISSIONS - DETERMINATION OF THE WATER VAPOUR IN DUCTS - STANDARD REFERENCE METHOD
    DIN EN 1911:2010-12 Stationary source emissions - Determination of mass concentration of gaseous chlorides expressed as HCl - Standard reference method
    DIN EN 12659:1999-11 LEAD AND LEAD ALLOYS - LEAD
    VDI 3882 Blatt 2:1994-09 Olfactometry - Determination of hedonic odour tone
    DIN EN 1179:2003-09 ZINC AND ZINC ALLOYS - PRIMARY ZINC
    TRD 604-1 : 2000 OPERATION OF STEAM BOILER PLANTS WITH STEAM GENERATORS OF GROUP 4 WITHOUT PERMANENT SUPERVISION
    EN 1976:2012 Copper and copper alloys - Cast unwrought copper products
    EN 13725:2003/AC:2006 AIR QUALITY - DETERMINATION OF ODOUR CONCENTRATION BY DYNAMIC OLFACTOMETRY
    EN 15259:2007 Air quality - Measurement of stationary source emissions - Requirements for measurement sections and sites and for the measurement objective, plan and report
    PREN 14181 : DRAFT 2012 STATIONARY SOURCE EMISSIONS - QUALITY ASSURANCE OF AUTOMATED MEASURING SYSTEMS
    EN 1978:1998 Copper and copper alloys - Copper cathodes
    TRD 604-2 : 1996 OPERATION OF STEAM BOILER PLANTS WITH HOT WATER GENERATORS OF GROUP 4 WITHOUT PERMANENT SUPERVISION
    VDI 4220:2011-04 Quality assurance - Requirements on bodies for the determination of air pollutants at stationary sources and in ambient air
    EN 12659:1999 Lead and lead alloys - Lead
    VDI 2448 Blatt 2:1997-07 Statistical evaluation of random-sample measurements of stationary source emissions: Determination of the upper confidence limit
    EN 13284-1:2017 Stationary source emissions - Determination of low range mass concentration of dust - Part 1: Manual gravimetric method
    EN 1981:2003 Copper and copper alloys - Master alloys
    VDI 1000:2017-02 VDI Standardisation Work - Principles and procedures
    VDI 3677 Blatt 1:2010-11 Filtering separators - Surface filters
    DIN EN ISO 23210:2009-12 Stationary source emissions - Determination of PM10/PM2,5 mass concentration in flue gas - Measurement at low concentrations by use of impactors (ISO 23210:2009)
    EN 15058:2017 Stationary source emissions - Determination of the mass concentration of carbon monoxide - Standard reference method: non-dispersive infrared spectrometry
    VDI 4285 Blatt 1:2005-06 Determination of diffusive emissions by measurement - Basic concepts
    EN 1948-1:2006 Stationary source emissions - Determination of the mass concentration of PCDDs/PCDFs and dioxin-like PCBs - Part 1: Sampling of PCDDs/PCDFs
    DIN EN 13284-1:2015-12 (Draft) STATIONARY SOURCE EMISSIONS - DETERMINATION OF LOW RANGE MASS CONCENTRATION OF DUST - PART 1: MANUAL GRAVIMETRIC METHOD
    DIN CEN/TS 14793:2005-06 STATIONARY SOURCE EMISSION - INTRALABORATORY VALIDATION PROCEDURE FOR AN ALTERNATIVE METHOD COMPARED TO A REFERENCE METHOD
    EN 1911:2010 Stationary source emissions - Determination of mass concentration of gaseous chlorides expressed as HCl - Standard reference method
    EN 1179:2003 Zinc an zinc alloys - Primary zinc
    DIN EN 12619:2013-04 Stationary source emissions - Determination of the mass concentration of total gaseous organic carbon - Continuous flame ionisation detector method
    EN 576:2003 Aluminium and aluminium alloys - Unalloyed aluminium ingots for remelting - Specifications
    VDI 3674:2013-04 Waste gas cleaning by adsorption - Process gas and waste gas cleaning
    VDI 4285 Blatt 2:2011-03 Determination of diffusive emissions by measurements - Industrial halls and livestock farming
    VDI 4219:2009-08 Determination of the uncertainty of emission measurements by use of discontinuous measurement methods
    EN 1977:2013 Copper and copper alloys - Copper drawing stock (wire rod)
    EN 14790:2017 Stationary source emissions - Determination of the water vapour in ducts - Standard reference method
    VDI 3676:1999-10 Inertial Separators
    DIN EN 14789:2006-04 STATIONARY SOURCE EMISSIONS - DETERMINATION OF VOLUME CONCENTRATION OF OXYGEN - STANDARD REFERENCE METHOD: PARAMAGNETISM
    DIN EN 14181:2015-02 Stationary source emissions - Quality assurance of automated measuring systems
    DIN EN 15058:2006-09 STATIONARY SOURCE EMISSIONS - DETERMINATION OF THE MASS CONCENTRATION OF CARBON MONOXIDE - STANDARD REFERENCE METHOD: NON-DISPERSIVE INFRARED SPECTROMETRY
    DIN EN 12861:1999-10 COPPER AND COPPER ALLOYS - SCRAP
    DIN EN 13725:2003-07 Air quality - Determination of odour concentration by dynamic olfactometry
    DIN EN 1976:2013-01 COPPER AND COPPER ALLOYS - CAST UNWROUGHT COPPER PRODUCTS
    VDI 3882 Blatt 1:1992-10 Olfactometry; determination of odour intensity
    VDI 2066 Blatt 1:1975-10 Particulate matter measurement; measuring of particulate matter in flowing gases; gravimetric determination of dust load; fundamentals
    DIN EN 14792:2006-04 STATIONARY SOURCE EMISSIONS - DETERMINATION OF MASS CONCENTRATION OF NITROGEN OXIDES - STANDARD REFERENCE METHOD: CHEMILUMINESCENCE
    EN 14792:2017 Stationary source emissions - Determination of mass concentration of nitrogen oxides - Standard reference method: chemiluminescence
    PREN 1977 : DRAFT 2011 COPPER AND COPPER ALLOYS - COPPER DRAWING STOCK (WIRE ROD)
    EN 1948-4:2010+A1:2013 STATIONARY SOURCE EMISSIONS - DETERMINATION OF THE MASS CONCENTRATION OF PCDDS/PCDFS AND DIOXIN-LIKE PCBS - PART 4: SAMPLING AND ANALYSIS OF DIOXIN-LIKE PCBS
    VDI 2450 Blatt 1:1977-09 Measurement of air pollutant emission, transmission, and immission; definitions and glossary of terms
    EN 573-3:2013 Aluminium and aluminium alloys - Chemical composition and form of wrought products - Part 3: Chemical composition and form of products
    DIN EN 15259:2008-01 Air quality - Measurement of stationary source emissions - Requirements for measurement sections and sites and for the measurement objective, plan and report
    VDI 3950:2006-12 Stationary source emissions - Quality assurance of automated measuring and electronic data evaluation systems
    • Access your standards online with a subscription

      Features

      • Simple online access to standards, technical information and regulations
      • Critical updates of standards and customisable alerts and notifications
      • Multi - user online standards collection: secure, flexibile and cost effective